PURSUIT 3000 OFFSHORE EXPRESS Instrukcja Właściciela

3000 EXPRESS3000 EXPRESSOWNER’S MANUALFISHING BOATS3901 St. Lucie Blvd.Ft. Pierce, Florida 34946Print Date 3/2000

3000 EXPRESSS2 Yachts will confirm, in writing, that the transfer of the warranty has taken place. After which,the transferee will be treated as the

3000 EXPRESS10.8 Transporting Your BoatThe Pursuit 3000 Express is a large boat and should only be trailered by professionals that have theknowledge

3000 EXPRESSChapter 11:EXTERIOR EQUIPMENT11.1 DeckRails and Deck HardwareThe rail system and hardware fittings have been selected and installed to p

3000 EXPRESSThe anchor locker is drained by thru hull fittings in the hull side near the bottom of the locker. Itis very important to check the drain

3000 EXPRESSWindshieldThe Pursuit 3000 Express is equipped with avented heavy duty aluminum windshieldwith tinted glass and built in hand rails. Thew

3000 EXPRESSTrim TabsThe trim tabs are recessed into the hull below the swim platform. The trim tabs are an importantpart of the control systems. Pl

3000 EXPRESSA large tackle locker is built into the helm seat base. The tackle locker is lockable and has fourstorage drawers.Ice MakerA 110-volt ic

3000 EXPRESSStern SeatA recessed fold down seat is built into the rear ofthe cockpit. To use the seat, release the latches bypulling sharply on the l

3000 EXPRESSUNDER NO CIRCUMSTANCES SHOULD THE HELM BE OPENED WHEN THE ENGINE(S)ARE RUNNING. IN SOME SITUATIONS IT IS POSSIBLE TO ACCIDENTALLY ENGAGE

3000 EXPRESSAttach the clear connector to the zipper at the front of the top and snap it to the brow and the topof the windshield frame beginning with

3000 EXPRESSThe warranty for the hard top or arch will be void if they are modified in any way or heavyaccessories like life rafts, or electronics loc

3000 EXPRESSOWNER'S/OPERATOR'SRESPONSIBILITIESRegistration and NumberingFederal law requires that all undocumented vessels equipped with pro

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSChapter 12:INTERIOR EQUIPMENT12.1 Head Compartment and Marine ToiletThe head compartment is equipped with a sink, hot and cold faucet tha

3000 EXPRESSThe vacuum generator is mounted on the holding tank and contains stored vacuum. Systemvacuum is monitored by a vacuum switch which is loc

3000 EXPRESSIN MANY AREAS IT IS ILLEGAL TO FLUSH HEAD WASTE DIRECTLY OVERBOARD. VIO-LATION OF THESE POLLUTION LAWS CAN RESULT IN FINES OR IMPRISONME

3000 EXPRESS12-4StoveThe galley is equipped with a single burner electric stove recessed into the counter top. To activatethe stove, make sure the st

3000 EXPRESS12.3 Convertible Dinette and TableThe dinette is on the starboard side ofthe cabin. It is equipped with a tableand two lounge seats that

3000 EXPRESSPlease read the owner's manual supplied by the detector manufacturer for operation instructions andadditional information regarding t

3000 EXPRESS12.5 V-BerthA large v-berth is located in bow area of the cabin forward of the dinette and hanging locker. Thereare storage compartments

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSChapter 13:ROUTINE MAINTENANCE13.1 Exterior Hull and DeckHull Cleaning-Below The Water LineWhen the boat is removed from the water, clean

3000 EXPRESSregulations. They can also help in providing local navigational information when moving to a newboating area. Contact your dealer, Stat

3000 EXPRESSBoats stored in salt water will normally need to have the anodes replaced every 6 months to oneyear. Anodes requiring replacement more fre

3000 EXPRESSAnodized Aluminum SurfacesAnodized aluminum should be washed periodically with soap and water to keep it clean. If the boatis used in sal

3000 EXPRESSDo not use the following on acrylic glass:Abrasive cleaners AcetoneSolvents AlcoholGlass cleaners Cleaners containing ammonia13.2 Upholste

3000 EXPRESSshorten the life of the vinyl that is used for clear curtains. After cleaning the curtains and allowingthem to dry, apply a non-lemon fur

3000 EXPRESS13-6ALWAYS READ THE LABEL CAREFULLY ON MILDEW PROTECTORS. REMOVE THEPROTECTOR AND ALLOW THE CABIN TO VENTILATE COMPLETELY BEFORE USINGTHE

3000 EXPRESSAvoid using fuels with alcohol additives. Gasoline that is an alcohol blend will absorb moisturefrom the air which can reach such concent

3000 EXPRESS• Frequently test the automatic bilge pump switch for proper operation. This is accomplished byinserting a stiff wire or small rod throug

3000 EXPRESSChapter 14:SEASONAL MAINTENANCE14.1 Lay-up and StorageBefore Hauling:• Pump out the head. Flush the holding tank using clean water and a

3000 EXPRESSLiftingIt is essential that care be used when lifting your boat. Make sure the spreader bar at each sling isat least as long as the dista

3000 EXPRESSSupporting The Boat For StorageA trailer or a well-made cradle is the best support for your boat during storage.When storing the boat on a

3000 EXPRESSTABLE OF CONTENTSChapter 1: Propulsion System Page1.1 General ...

3000 EXPRESS• Remove all oxidation from the exterior hardware, and apply a light film of moisture displacinglubricant.• Remove propellers and grease t

3000 EXPRESSfrom all freshwater faucets. Be sure to open all hot and cold water faucets, including the freshwatershower in the cockpit and the faucet

3000 EXPRESSNote: Make sure you follow the marine toilet manufacturer's winterizing instructionsexactly.Air ConditionerDisconnect and drain the a

3000 EXPRESS14-7Special Notes Prior To Winter StorageIf the boat will be in outside storage, properly support a storage cover and secure it over the b

3000 EXPRESSMAKE SURE THE MUFFLERS HAVE NOT BEEN DAMAGED DURING WINTER STORAGEAND THAT THE DRAIN PLUGS ARE INSTALLED AND PROPERLY TIGHTENED. LOOSEOR

3000 EXPRESS• Carefully monitor the gauges and check for leakage and abnormal noises.• Operate the boat at slow speeds until the engine temperature st

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSChapter 15:SCHEMATICS15-112-Volt Wiring Schematic

3000 EXPRESS15-2110-Volt Wiring Schematic

3000 EXPRESSBattery Cable Schematic15-3

3000 EXPRESSTABLE OF CONTENTSChapter 4: Electrical SystemPage4.1 General ...

3000 EXPRESS15-4Hydraulic Steering System

3000 EXPRESS15-5Gas Fuel System

3000 EXPRESS15-6Diesel Fuel System

3000 EXPRESSFresh Water System15-7

3000 EXPRESSBridge Deck Raw Water System15-8

3000 EXPRESS15-9Head Plumbing System

3000 EXPRESS15-10Running GearRudder AssemblyShaftTransmissionCouplerShaftCouplerCoupler AssemblyProp AssemblyShaftPropellerKeyProp NutsCotterKey

3000 EXPRESSShaft Seal Assembly15-11

3000 EXPRESS15-12 Drainage System

3000 EXPRESS Bridge Deck Drainage System Bridge Deck Plumbing15-13

3000 EXPRESSTABLE OF CONTENTSChapter 8: Ventilation System Page8.1 Cabin Ventilation ...

3000 EXPRESSSling Positions15-14

3000 EXPRESSGas Exhaust System15-15

3000 EXPRESSDiesel Exhaust System15-16

3000 EXPRESSAPPENDIX A:GLOSSARY OF TERMSAft: In, near, or toward the stern of a boat.Aground: A boat stuck on the bottom.Amidship: In or toward the

3000 EXPRESSBoat Hook: Short shaft of wood or metal with a hook fitting at one end shaped to aid in extendingone’s reach from the side of the boat.Bo

3000 EXPRESSDeck: The floor-like platform of a boat that covers the hull.Displacement: The volume of water displaced by the hull. The displacement

3000 EXPRESSGround Tackle: A general term including anchors, lines, and other gear used in anchoring.Grounds: A boat touches the bottom.Gunwale: Th

3000 EXPRESSLength On The Waterline (l.w.l.): A length measurement of a boat at the waterline from the sternto where the hull breaks the water near t

3000 EXPRESSPitching: The fore and aft rocking motion of a boat as the bow rises and falls.Pitch: The measure of the angle of a propeller blade. Re

3000 EXPRESSSeacock: Safety valves installed just inside the thru-hull fittings and ahead of the piping or hoserunning from the fittings.Shaft Log:

3000 EXPRESSTABLE OF CONTENTSChapter 12: Interior EquipmentPage12.1 Head Compartment and Marine Toilet ...12-112.2 Gall

3000 EXPRESSThru-hull: A fitting used to pass fluids (usually water) through the hull surface, either above orbelow the waterline.Topsides: The side

3000 EXPRESSAppendix B:HoursDate DealerService/RepairsMAINTENANCE LOGB-1

3000 EXPRESSHoursDate DealerService/RepairsMAINTENANCE LOGB-2

3000 EXPRESSHoursDate DealerService/RepairsMAINTENANCE LOGB-3

3000 EXPRESSHoursDate DealerService/RepairsMAINTENANCE LOGB-4

3000 EXPRESSHoursDate DealerService/RepairsMAINTENANCE LOGB-5

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSC-1BOATING ACCIDENT REPORTFORM APPROVEDOMB NO.211-0010DEPARTMENT OFTRANSPORTATIONU.S. COAST GUARDC.G. 1865 (REV. 1/88)The operator/owner o

3000 EXPRESSC-2If more than 3 fatalities and/or injuries, attach additional form(s)WAS VICTIM?[ ] Swimmer[ ] Non SwimmerDATE OFBIRTHADDRESSNAME DEAT

3000 EXPRESSTABLE OF CONTENTSChapter 15: SchematicsPage12-Volt DC Wiring Schematic ...15-1110-Vol

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSChapter 1:PROPULSION SYSTEM1.1 GeneralThe Pursuit 3000 Express is designed to be powered with twin gasoline or diesel inboard engines.Each

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESS1.2 Drive SystemsOn inboard propulsion systems, all shifting and gearing components are installed inside the hull.Only the propeller shaft

3000 EXPRESSInboard boats use the exhaust system to relinquish exhaust gases and cooling water. A periodicinspection of the hoses, mufflers and relat

3000 EXPRESS• Reassemble the strainer making sure that all fasteners are tight.• Open the intake valve.• Start the engine and inspect the strainer for

3000 EXPRESSStep 2: Install the key in the shaft.Step 3: Again, slide the propeller into position by hand. Please note that the key should not extend

3000 EXPRESS1-61.6 Running GearShaft Logs and Dripless SealThe shaft logs, which are fastened into the hullbottom, allow the propeller shaft to extend

3000 EXPRESSStrutsThe struts are the metal castings bolted to the bottom of the hull to secure the aft end of the propellershafts. A replaceable cutl

3000 EXPRESSStep 2: Hold the propeller shaft flange firmly against the transmission flange.Step 3: Try to insert a .004" feeler gauge at the top,

3000 EXPRESS1.7 Engine InstrumentationThe helm station is equipped with a set of engine instru-ments and/or alarms. These instruments allow the pilot

3000 EXPRESS1-10VoltmeterThe voltmeter displays the voltage for the battery and the charging system. The normal voltage is11 to 12 volts with the eng

3000 EXPRESS1-11CompassThe compass is on top of the console. To adjust the compass foryour area, read the instructions on “Compass Compensation”given

3000 EXPRESS iDear Pursuit 3000 Express Owner:All of us at Pursuit are pleased that you have selected one of our products asyour boat. As I’m sure yo

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSControlsChapter 2:HELM CONTROL SYSTEMS2.1 GeneralThe helm controls consist of three systems: the engine throttle and shift controls, the

3000 EXPRESSthe throttles so that the engines are running the same RPM (synchronized) can be done by listeningto the engine sounds, or with an engine

3000 EXPRESSIN SOME SITUATIONS, IT MAY BE POSSIBLE TO ACCIDENTALLY START THE ENGINESIN GEAR WITH THE THROTTLES ABOVE IDLE IF THE NEUTRAL SAFETY SWITCH

3000 EXPRESS2.6 Trim TabsThe trim tabs are recessed into the hull on the transom. A dual rockerswitch is used to control the trim tabs. The switch i

3000 EXPRESS2.7 Control Systems MaintenanceControl MaintenancePeriodic inspection of the control systems and all connections should be made. Signs of

3000 EXPRESSTrim Tab MaintenanceMarine growth can interfere with the proper operation of the trim tab planes and actuators. Toreduce problems due to

3000 EXPRESS3-1Diesel Fuel SystemChapter 3:FUEL SYSTEM3.1 GeneralThe fuel system used in Pursuit boats is designed to meet or exceed the requirement

3000 EXPRESS3-2Fuel FillFuel Withdrawal TubesThe fuel withdrawal tubes are positioned in the fuel tanks to achieve optimum fuel usage, fuel lineroutin

3000 EXPRESSFuel Valves3-33.2 Gasoline Engine Fuel SystemThe fuel system on the Pursuit 3000Express has two fuel tanks and twomanual fuel valves. The

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESS3-4Gasoline Fuel FilterEach gasoline engine is equipped with a spin on, water separator typefuel filter. The filter should be checked fre

3000 EXPRESS3-53.3 Diesel Engine Fuel SystemThe diesel fuel system works much like the gas system. The main difference is the diesel systemis not equ

3000 EXPRESS3-63.4 Fueling InstructionsFUEL IS VERY FLAMMABLE AND CAN CAUSE A FIRE OR AN EXPLOSION. BE CARE-FUL WHEN FILLING THE FUEL TANKS. NO SMOK

3000 EXPRESSSTATIC ELECTRICITY CAN BE GENERATED WHILE FUELING AND CAN CAUSE A FIREOR EXPLOSION. TO PREVENT STATIC SPARKS WHEN FILLING THE TANK, MAKE

3000 EXPRESS3-83.5 Fuel System MaintenancePeriodically inspect all connections, clamps and hoses for leakage and damage or deterioration.Replace as ne

3000 EXPRESSDO NOT DRAIN ANY FUEL INTO THE BILGE. THIS COULD LEAD TO A FIRE OR EX-PLOSION.AFTER THE FILTER ELEMENT HAS BEEN CHANGED, PRIME THE FUEL SY

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSChapter 4:ELECTRICAL SYSTEM4.1 GeneralYour Pursuit is equipped with 110-volt AC and 12-volt DC electrical systems. The AC system candra

3000 EXPRESSPROPER FUSE OR BREAKER PROTECTION MUST BE PROVIDED FOR ALL 12-VOLTEQUIPMENT ADDED. DO NOT OVERLOAD THE ACCESSORY CIRCUIT BREAKERS OROTHER

3000 EXPRESSNote: Current is supplied to the automatic float switches for the bilge pumps when thebatteries are connected and the battery switches are

3000 EXPRESSSAFETY INFORMATIONYour 3000 Express Owner’s Manual has beenwritten to include a number of safety instructions to assure thesafe operation

3000 EXPRESSCockpit LightsActivates the lights that illuminate the cockpit area.Spreader LightsActivates the flood lights located on the optional rada

3000 EXPRESSTrim Tab SwitchLocated in the helm. This switch controls the trim tab planes located on the transom of the boat. Itis protected by the 20

3000 EXPRESSHolding Tank MaceratorThe holding tank overboard discharge macerator switchpanel is located in the head compartment next to theholding tan

3000 EXPRESSStereoSupplies 12-volt electrical current to the stereo.TV/VCPSupplies 12-volt electrical current to the TV and accessory plug in the cabi

3000 EXPRESSCARBON MONOXIDE IS A LETHAL, TOXIC GAS THAT IS COLORLESS AND ODORLESS.IT IS A DANGEROUS GAS THAT WILL CAUSE DEATH IN CERTAIN LEVELS.Shower

3000 EXPRESS4-9AB Switch (Optional)Used to switch the TV between the antenna and the dockside cable, whenever the optional TV andTV antenna are instal

3000 EXPRESS4-10Turn the dock side disconnect switch or circuit breaker to the “ON” position and check for properpolarity. If reverse polarity has be

3000 EXPRESS110-Volt AC Accessory Breaker PanelThe AC panel is located in the cabin.The following is a description of theAC panel equipment and the br

3000 EXPRESSStoveSupplies electrical current directly to the galley stove.Battery ChargerSupplies electrical current directly to the automatic battery

3000 EXPRESSside power. Move the selector switch to the “OFF” position when disconnecting the dock sidepower or when no 110-volt AC power is being su

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSKeep the battery tops clean and dry. Dirt and water can conduct electricity from one post to theother causing the battery to discharge.Th

3000 EXPRESSChapter 5:FRESH WATER SYSTEM5.1 GeneralThe fresh water system consists of a potable water tank, distribution lines and a distribution pum

3000 EXPRESS5.2 Fresh Water System OperationFill the water supply tank slowly through the labeled deck plate. After fillingthe water tank, partially

3000 EXPRESS5-3A high pressure relief valve protects the system from excessive pressure. Always make sure all airis purged from the water heater and

3000 EXPRESS5-4Shower water is drained from the head compartment by a sump pump system connected to theshower drain. An automatic float switch in the

3000 EXPRESSTHE WATER PRESSURE BREAKER SHOULD BE PLACED IN THE “OFF” POSITION WHEN-EVER LEAVING THE BOAT UNATTENDED OR WHEN THE FRESH WATER SYSTEM ISN

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSChapter 6:RAW WATER SYSTEM6.1 GeneralIn the raw or sea water systems, all water pumps are supplied by hoses connected to ball valves andt

3000 EXPRESS6-26.2 High Pressure WashdownA saltwater high pressure pump, controlled by a pressure sensor, supplies theraw water hose connector located

3000 EXPRESS6.3 LivewellSea water is provided to the livewell by a 12-voltdiaphragm pump. This pump is designed to carry aconstant flow of water to t

3000 EXPRESSiiiBOAT INFORMATIONMAKE:SERIAL #:MODEL:GVRW:PHONE:REPRESENTATIVE:TRAILERNAME:DEALER/PHONE:ADDRESS:SERVICE MANAGER:ADDRESS:SALESMAN:DEALER

3000 EXPRESSdamage the pump or the air conditioning system. Make sure the sea water pump receives adequatesea water by periodically cleaning the sea

3000 EXPRESSChapter 7:DRAINAGE SYSTEMS7.1 GeneralAll water is drained by gravity to overboard thru hull fittings located in the hull sides above the

3000 EXPRESS7.2 Cockpit DrainsYour Pursuit has two scupper drains located in the rear of the cockpit. Water is channeled awayfrom all hatches by a gu

3000 EXPRESSA LOOSE DRAIN PLUG WILL ALLOW SEA WATER TO ENTER THE BILGE AND COULDCAUSE THE BOAT TO SINK. IT IS VERY IMPORTANT TO CHECK THE DRAIN PLUGF

3000 EXPRESS7.7 Shower and Cabin Sink DrainsThe shower and cabin sinks are drained from theboat by a sump pump system connected to theshower and sink

3000 EXPRESS• Clean and inspect the shower and cabin sink drain sump system. Remove accumulated debrisand flush with freshwater. Frequently test the

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSChapter 8:VENTILATION SYSTEM8.1 Cabin VentilationVentilation to the cabin area is provided by three deck hatches and opening port windows.

3000 EXPRESS8-28.3 Carbon Monoxide and Proper VentilationFAILURE TO PROPERLY VENTILATE THE BOAT WHILE THE ENGINES ARE RUNNINGMAY PERMIT CARBON MONOXID

3000 EXPRESSACTUATION OF THE CARBON MONOXIDE DETECTOR INDICATES THE PRESENCE OFCARBON MONOXIDE (CO) WHICH CAN BE FATAL. EVACUATE THE CABIN IMMEDI-ATE

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESS8.5 Maintenance• Periodically lubricate all hinges and latch assemblies with a light oil.• Periodically clean and coat gasket materials wi

3000 EXPRESSChapter 9:SAFETY EQUIPMENT9.1 GeneralYour boat and inboard engines have been equipped with safety equipment designed to enhance thesafe o

3000 EXPRESS• Monitor the engine gauges to determine the cause of the problem.• If necessary, shut off the engines and investigate until the cause of

3000 EXPRESSVisual Distress SignalsAll Pursuit boats used on coastal waters, the Great Lakes, territorial seas, and those watersconnected directly to

3000 EXPRESSSound Signaling DevicesThe navigation rules require sound signals to be made under certain circumstances. Recreationalvessels also are r

3000 EXPRESSsituation, make sure all passengers have a life preserver on and go over the side and swim wellupwind of the boat. This will keep you and

3000 EXPRESSIF THE AUTOMATIC FIRE EXTINGUISHING SYSTEM IS INSTALLED IN YOUR BOAT, THEINFORMATION PROVIDED BY THE SYSTEM MANUFACTURER SHOULD BE INCLUDE

3000 EXPRESSDrug or alcohol use increases the effect of CO exposure. Individuals with cardiac or respiratoryconditions are very susceptible to the da

3000 EXPRESS9.7 First AidIt is the operator's responsibility to be familiar with the proper first-aid procedures and be able to care for minor in

3000 EXPRESSAdditional Equipment to Consider:VHF Radio Life Raft Spare AnchorHeaving Line Fenders First Aid KitFlashlight Mirror SearchlightSunburn Lo

3000 EXPRESSIMPORTANT INFORMATIONWarranty and Warranty Registration CardsThe Pursuit Limited Warranty Statement is included with your boat. It has be

3000 EXPRESSTHIS PAGE WAS LEFT BLANKINTENTIONALLY

3000 EXPRESSChapter 10:OPERATION10.1 GeneralBefore you start the engines on your Pursuit, you should have become familiar with the variouscomponent

3000 EXPRESS10-2including rules of the road. We strongly recommend such courses. Books or videos on this subjectalso are available from your local l

3000 EXPRESS10-310.3 Pre-Cruise CheckBefore Starting the Engines:• Check the weather forecast. Decide if the planned cruise can be made safely.• Be

3000 EXPRESS10-4• Have a tool kit aboard. The kit should include the following basic tools:Spark Plug Wrench HammerSpark Plug Gap Gauge Electrician’s

3000 EXPRESS10-5After Starting the Engines:• Check the engine gauges. Make sure they are reading normally.• Visibly check the engines to be sure ther

3000 EXPRESS10-6DO NOT OPERATE THE BOAT UNLESS IT IS COMPLETELY ASSEMBLED. KEEP ALLFASTENERS TIGHT. KEEP ADJUSTMENTS ACCORDING TO SPECIFICATIONS.• A

3000 EXPRESS10-7• Fill the fuel tanks to near full to reduce condensation. Allow enough room in the tanks f o rthe fuel to expand without being force

3000 EXPRESS10.6 FishingFishing can be very exciting and distracting for the operator when the action gets intense. You mustalways be conscious of t

3000 EXPRESS• Do not operate the boat in tight quarters, such as marinas, from the tower. The operator isisolated from the boat while in the tower an